Free written scope consultation - allowances, timeline, and change-order rules on paper before a single trade is scheduled
Kohler Driveway & Pavers: The Orlando Owner’s Guide
If you have a Kohler product tied to your driveway or paver system in Orlando and the part failed, we can match it, price it honestly, and install it right. Most Kohler-compatible paver and driveway repairs in the Orlando market run between $250 and $700 for sealing and surface work, while a full paver driveway installation lands between $7,000 and $18,000 depending on square footage, base condition, and access. You’ll usually notice the problem first as a sunken paver near the driveway edge, a loose Kohler drain channel that no longer sits flush, or water pooling where it used to run off clean.
We’re an independent service provider, not affiliated with Kohler directly. But we work with their specification-grade product lines every week, and we stock the common replacement parts Orlando homeowners actually need on the truck.
Which Kohler Models This Applies To
Kohler’s outdoor living division produces paver systems, trench drains, and channel solutions used across Orlando driveways, pool decks, and patio hardscapes. The compatibility gotcha most owners hit: Kohler drainage components are engineered to specific grate load ratings and channel widths. A residential driveway typically needs a Class B or Class C load-rated grate. If you grab a Class A grate meant for pedestrian foot traffic and set it in your driveway, it will crack the first time an SUV rolls over it.
When you look at the part, you’ll find the Kohler model or series identifier molded into the underside of the grate or along the channel edge. Write that down or take a photo before you call. The number tells us the channel width, the locking mechanism type, and whether you need an OEM replacement or whether a quality aftermarket equivalent from a manufacturer we trust will match the load spec and fit the same seat. For Kohler specifically, we lean OEM when the part is still in production because their locking tabs and grate-to-channel tolerances are tight enough that a generic swap sometimes rattles under traffic.
If you also have KraftMaid, Cambria, or Silestone elements tied into outdoor kitchen areas near your driveway, we can source those parts too.
Styles & brands we work with
Signs Your Kohler Driveway & Pavers Are Failing
- Water pooling against the garage slab after rain. This usually means the Kohler channel drain under the driveway edge is clogged, cracked, or the grate has shifted out of its seat. In Orlando’s afternoon downpours, that standing water works its way under the pavers and starts eroding the base.
- A paver that rocks or dips when you step on it. The sand bedding underneath has washed out or compacted unevenly. If you catch it early, we reset the paver and re-screed the bed. If you wait, the adjacent pavers start shifting too.
- Cracks radiating from a single paver near the driveway entrance. Cars turn here, and that repeated torque load cracks weak pavers first. Florida’s heat cycles expand and contract the surface, and a paver with a hairline crack today will split by August.
- Rust staining or a grating sound when you drive over the drain channel. The Kohler grate is loose or the frame has separated from the channel body. The grating sound is metal on metal, and every car that crosses it is chewing up the seat edge.
- Ant mounds surfacing between pavers. Orlando’s sandy soil makes this common. The ants aren’t just unsightly; they’re excavating the bedding layer from underneath, which is why you see settlement in the same spot a month later.
See the difference
Before
After
Before
After
Before
AfterReplacement Cost & What’s Included
In Orlando, you’ll pay $250 to $700 for driveway sealing and minor paver reset work. A full paver driveway installation runs $7,000 to $18,000, and concrete driveway installation lands between $4,500 and $12,000. Where your job falls depends on the square footage, the condition of the existing base, whether we’re pulling and reusing pavers or setting new ones, and access for equipment.
What drives the price most is what’s under the pavers. If the base is still solid and we’re swapping a failed Kohler drain channel plus a few reset pavers, you’re on the low end. If water has been running under the driveway for a year and the base has turned to soup, we’re digging it out and rebuilding from the subgrade up.
Every price is written. You’ll see the parts, the labor, the disposal, and the base work as separate line items before any work starts. And the work carries our 365-Day Done Right Promise: if something isn’t right within a year of completion, we make it right at no cost to you.
DIY or Call Us?
You can safely pull a Kohler grate off the channel and clean out the leaves and sand that collected under it. That’s a five-minute job with a flathead screwdriver and a bucket. You can also sweep sand back into paver joints if you catch a small gap early.
What you shouldn’t do is lift paver sections and try to re-compact the base yourself. It looks simple, but without a plate compactor and the right bedding mix, you’ll set the paver high or low, and Orlando’s rain will undo your work in one season. Drain channel replacement involves cutting into the surrounding pavers cleanly, and if you nick the wrong edge, you’re now replacing three pavers instead of one grate.
Tell me what the problem is. We’ll figure out the rest from there. Call (850) 920-7745 and we’ll walk you through what you’re seeing.
FAQs
A properly installed paver driveway in Orlando lasts 25 to 40 years, but the Kohler drain channel grate typically needs replacement or a deep clean every 8 to 12 years because of UV exposure, vehicle loading, and our sandy soil working into the seat. If the base was built right, the pavers usually outlast the drainage components. Call (850) 920-7745 for an exact quote; estimates are free.
Sometimes. A cracked grate can’t be repaired safely, but a channel that’s just clogged or a paver that’s simply settled can often be reset or cleaned without buying new parts. We’ll tell you which one you’re looking at once we see it. Call (850) 920-7745 and we’ll give you a straight answer.
A single drain channel grate swap or a few reset pavers is usually a half-day job. A full paver driveway replacement in Orlando takes three to seven working days depending on the square footage and whether we’re hauling out the old base. We’ll give you a written timeline with your written price.
We stock the common Kohler channel grates, locking tabs, and paver edge restraints on the truck. Specialty sizes or older discontinued models may take a few days to source from our supplier network. We’ll tell you before we schedule anything. Call (850) 920-7745 for a free estimate.
Written by Isaac Pruett, Owner, Mason Remodeling Co Orlando at Mason Remodeling Co Orlando, serving Orlando and nearby areas.
